Volkswagen Jetta owners have reported 59 The car has about 70,000 mi. Subsequent to the recall campaign, the lower egr flex pipe is known to crack on numerous vehicles in which the recall campaign was performed. ©2020, CarProblemZoo.com All rights reserved. Kb. I had to call vw for an update as they had not called me and they said it might be because of bad gas (which I know is not the issue as it has been doing this for over a year). 2. It also stalls out when sitting at an intersection. Includes: 1 x Elbow joiner. Tl- the contact owns a 2009 Volkswagen Jetta. Dorman Products - 598-601 : Exhaust Gas Recirculation Tube. Includes 2 paper-type EGR gaskets for both ends of the cooler. According to the dealer the problem is with the ignition coil, and that vw is aware of the problem and are recalling certain models. We were very lucky to not get hit from behind. EGR Valve May Qualify For FREE SHIPPING. Not cover by warranty all these happened by 05/07. They wanted 150.00 to carry out a overnight pressure test, so you can imagine my response to that…. This pipe will break if the EGR cooler is not bolted down properly. Wahler BorgWarner EGR Cooler Pipe $85.00. I don't remember how exactly he described it, but it was like a leaking air sound. The vehicle was take for a state emission inspection but failed the test. 00. The lower egr cooler pipe #038131521cc. This pipe cracks causing improper emissions and exhaust gases into the engine compartment next to the cabin air filter intake. See You must log in or register to reply here. The vehicle was taken to the dealer. The manufacturer was made aware of the failure. 1. The consumer stated that the vehicle was parked. This is the second time this same problem has happened in first 20k miles of this vehicle its an 2010 vw tdi. He offered to look into it further, but I didn't want to pay the labor charges without knowing the problem. This was reported to platinum Volkswagen on 1/6/09 during a vehicle courtesy check. Now its 10/08 and I have 84,000 miles. Purchased this car new in 2011. See Dealer paid to fix rim broke 2 weeks later the dealer paid fo used set of similar rims. VW 2006 Jetta Turbo Diesel 190,000 Miles 2nd owner P0299 Turbo Underboost - replaced EGR Valve, EGR Cooler, Black Smoke - Answered by a verified VW Mechanic. When driving on the interstate at 65 mph my car suddenly lost all its power and was I could not go over 25 mph. I have a 2006 jetta tdi… Also car stalled several times on its own while idling at a traffic light (its an automatic transmission this should not be happening). The failure mileage was 60,000 and the current mileage was 110,000. There is a continuing problem with the exhaust system. This strong smell is causing my kids to cough and is unbearable. The vehicle was taken to the dealer and they stated that it was due to the engine exhaust flap failure. These often start leaking, causing the car to loose coolant. Replaced 3 cracked parts in 1 year. The contact noticed a fuel odor from the trunk area. Complete BRM EGR cooler bypass kit. Volkswagen Jetta (2006-2010) Exhaust Gas Recirculation (EGR) The EGR system recirculates exhaust gas back to the cylinders, helping the car to meet emissions regulations. For Volkswagen Jetta 2005-2006 TDI EGR Cooler Premium 03G131512AD (Fits: 2006 TDI) ... 1 product rating - 2006 VOLKSWAGEN JETTA EGR COOLER HOUSING PIPE HOSE EXHAUST TUBE 06 TDI OEM. all problems of the 2014 Volkswagen Jetta . Swaybar bushing fell out causing grinding and shaking when ever moving. Engine would not start, so owner jump-started it and let it run approximately 5 minutes. Owner tried to start engine after vehicle sitting unused for one week. Poison gases in the vehicle interior. Installing an EGR delete on 2006 and up 6.0L trucks WILL result in the check engine light. The most recently reported issues are listed below. all problems of the 2013 Volkswagen Jetta . Vw is clearly aware of the problems and should accelerate their recall campaign on this issue. The car dealer could not find the problem; however, the problem continues. Also, the contact mentioned after getting the vehicle back from the dealer, the engine warning light was illuminated. Under my recommendation camshaft was inspected and found to be defective as well as the lifters that contact the camshaft. Smell is originating from rear of engine, smell is pure un treated diesel exhaust. Present problem is caused by another recalled defective problem. See Driver window switch goes up when you push down and down when you push down have to fiddle with it for it to go up. Call (888)280-7799. The vehicle was taken to the dealer where it was diagnosed that the engine exhaust flap needed to be replaced. . Question is, has anyone ever seen, or found evidence that the EGR coolers do leak. ... (2004-2006) Jetta TDI MkIV (A4 chassis) w/ BEW Engine (2004-2005) Jetta Wagon TDI (A4 chassis) w/ BEW Engine (2004-2006) New Beetle TDI (A4 chassis) w/ BEW Engine (2004-2006) Frequently Asked Questions Ask us a question. The vehicle was put in reverse and it started bucking and making a lot of noise. This is a safety issue that could easily cause a collision and when parts become available, we will have the ignition coil replaced. Dealer has replaced several components but to no avail. When we took it to the dealer the service manager refused to let us drive it due to the possibility of an engine fire. Vacuum leak in the EGR valve in my 2006 Jetta TDI 180000miles runs great can I just plug the leak with epoxy or what Posted by lepakw on Sep 21, 2011 Want Answer 0 I took it back, they replaced it and it failed again. Vwoa says it is ok for me to breathe diesel fumes. In fact, it will set the check engine light on all Ford 6.0L's with software that has been updated since about 2005. all problems of the 2005 Volkswagen Jetta . Well he never did find the prob, but he took it to the dealer to get diagnosed. The manufacturer was made aware of the issue. VW EGR cooler. This is very dangerous when it happens in traffic. He's located in Alb NM as is the dealer. The also advised the car is showing intermittent code of p0638 for throttle actuator control (bank 1). Radio still isn't fixed so I just went and bought an after market. problems related to engine exhaust system (under the engine and engine cooling category). I purchased a 2014 vw Jetta, brand new from vw boise in idaho. Volkswagen is denying claims to replace these exhaust restrictor valves when they fail, and is asking customers to pay for replacement. They checked this when I got an oil change and they said it was just low coolant. Vwoa had a recall campaign for the egr cooler system on 2004 and 2005 vw tdi's. this smell occurs very often (several times a day) when the car accelerates rapidly (for example, when passing another car etc. ) He told me that one of oxygen sensor is faulty now caused by exhaust flap problem and said it is not covered by recall and asked to pay $550. 2009-2013 model year Volkswagen tdi vehicles sold in the united states contain an exhaust restrictor valve that controls the regenerative feature of the diesel particulate filter (dpf). 1. I would buy another car but I simply can't afford it. all problems of the 2004 Volkswagen Jetta . Improper installation of the Volkswagen m6 recall. When I took my vehicle back to get a recall done the light had come on again and this time it turned out the oil cooler had a leak. This problem can cause major engine damage and is caused. Tl the contact owns a 2012 Volkswagen Jetta. Vw refused to correct the problem. On 3 occasions, I reported an issue with the car shaking/losing acceleration power while driving (a serious safety issue). Volkswagen Jetta TDI 2006, EGR Valve by Pierburg®. Dealership refused to fix the problem with the 2001 Volkswagen Jetta. vehicle stalled a few time in traffic almost causing an accident with other vehicles Removing the EGR cooler from the cooling system solves this. statistics and reliability analysis of Volkswagen Jetta, all problems of the 2012 Volkswagen Jetta, all problems of the 2010 Volkswagen Jetta, all problems of the 2014 Volkswagen Jetta, all problems of the 2009 Volkswagen Jetta, all problems of the 2011 Volkswagen Jetta, all problems of the 2013 Volkswagen Jetta, all problems of the 2006 Volkswagen Jetta, all problems of the 2005 Volkswagen Jetta, all problems of the 2000 Volkswagen Jetta, all problems of the 2002 Volkswagen Jetta, all problems of the 2001 Volkswagen Jetta, all problems of the 2004 Volkswagen Jetta, all problems of the 2003 Volkswagen Jetta. C $217.50. Are the EGR valves problematic? Diesel exhaust smell enters cabin through interior climate control vents. Volkswagen of marietta (1860 cobb pkwy se, marietta, GA 30060, (770) 955-6565) previously diagnosed that the diesel particulate air filter failed and stated that the part needed to be replaced again. I also was not given a loaner because they stated that they had none available. Luckily, there was recall on the same a month later. Dealership performed 90k mile checkup. all problems of the 2011 Volkswagen Jetta . In October 2015, I had it in for service and explained the situation to them again, they assured me that a software update would fix it. I have a 2006 Jetta tdi, failure occurred on interstate I - 65 on 7/1/09 I heard a pop as if something fail out from under the car , all the oil dropped out of the vehicle all over the interstate for approximately 1 to 2 miles. I have a 2005 volkswagon Jetta my husband was driving the car and the battery blew up under the hood. BuzzKen. I am a loyal Volkswagen owner and this is the second vw I have owned and I never had a problem with any of the other cars. It seems to be a repeat problem with this vehicle and very dangerous to have it slow down like that while driving and also stall out while in traffic. 2. Vwoa has refused to address the problem and offers no solution to the vehicle owner or a fix. The only way I can describe it is that it smells like burning crayons. Written on the estimate by vw dealership is "technician noted that while driving vehicle into the shop, vehicle had no throttle control and would not increase in engine speed. On the highway, the car performs quite well--good engine power, steering, etc. all problems of the 2001 Volkswagen Jetta . If there is anything you can do to help it would be greatly appreciated you. After I returned home, I disconnected the lower intercooler hose to find a large ice formation and water restricting the outlet of the intercooler. Unfortunately at over 75000 miles and 8. Every vw with this style intercooler setup has potential for this problem. I am very disappointed that it appears vw knows about this issue and is ignoring the issue. A friend's '06 developed a sound upon acceleration. Keyless entry only works within 4ft of the car. Speakers still shortening out only when its cold out. The Volkswagen dealership has repaired it over and over again. The dealer refused to replace the mass air flow sensor under the extended warranty. all problems of the 2010 Volkswagen Jetta . 2006 Jetta Egr Cooler Pipe Leak A friend's '06 developed a sound upon acceleration. Another issue of a problem with the EGR cooler is exhaust leaks. Total job quoted at $1000. Ours has not had the recall as of 11/1/09. I have had 27 things break or fail on my 03vw Jetta 1. 3. Removing coolant from the cooler has no ill effects on the motor. The repair costs more than $1000 and I am unable to pass state inspection without getting it done. Plastics and carpet on center floor of passenger compartment were burned. Engine light came on again and dealer stated that the particulate filter and catalytic converter both needed to be replaced. I find that hard to believe. Per the service manger the oil leak was causing an atomization of the engine oil that could have reached heated parts of the egine or exhaust and caused an oil fire. The steering wheel was not steering correctly. Smell enters cabin when vehicle is stationary, worse when cold or when engine is in the midst of a diesel particulate filter regeneration. If I drive for more then an hour I get sick and light-headed. The check engine light came on, but only after causing serious damage to the engine, which was not covered under warranty on a two year old car. EGR cooler for A5 TDI with engine code BRM. They told him it was the EGR valve and pipe. I don't remember how exactly he described it, but it was like a leaking air sound. First two months 2 tires blew out, front rim cracked, back tires out of alignment. ". I'm doubtful of anything they say needs replaced. Driving normally on highway when it came on and the car lost power suddenly and could not accelerate any further. See They said they would call me before close of business on 12/03 with another update. Now, I can't even inspect the car. I had to wait over 25 minutes before I was able to speak with a rep from vw roadside and then I had to wait an additional hour before the tow truck would be able to tow my car. 3. Can a leaking EGR cooler on a Jetta TDI w/BRM motor cause acceleration hesitation presenting itself like a boost leak? all problems of the 2003 Volkswagen Jetta . Dealer says this is not a vw problem and was surprised to see a problem with the camshaft. 00. ... 2005 and 2006 TDI by BuzzKen (AAR547) $399.99. The exhaust flap is sticking in the open position, thus causing warning light on dash to come on. On 12/02/2015, I was driving to pick up my daughter after work and a car in front of me was turning. Very strong exhaust/foul smell inside vw Jetta car upon rapid acceleration These two hoses are bonded together and have a heat-resistant covering. The interior lighting does not turn on or off with the opening of a door. This 2006-2010 iteration of the Jetta is larger and more expensive than its predecessor. I am getting really worried that one of these days something really bad is going to happen,and I may be injured. But I cannot pass CA smog testing for the new Snap Bar test. The manufacturer provided the consumer with an extended warranty for the mass air flow sensor to 7 years/70000 miles, whichever occurs first. all problems of the 2002 Volkswagen Jetta . However, the non-starting after being driven a distance could result in being stranded and placed in danger. Volkswagen customer service representatives say they have never heard of this problem. Radio stopped working front door speakers are shorting out. How can they get away with selling a brand new car for $28k to have it crap out with no repercussions like this?. To order Block Off Kit or need advice about video email directly to itispossiblevideos.comNeeding to delete your erg cooler? See In order to be able to comply with future emission limits, stiff requirements are applied to engine systems. I let off of the brake and lightly pressed the gas to accelerate and the car started shaking violently. This complaint is for a 2009 v. W. Tdi (diesel engine). Very dangerous problem, car very unreliable!!. Refusing to send lead tech out to investigate. They suggested replacing the EGR cooler first, then the head if the leak still persists. The contact stated that the engine light illuminated. Vw says they know it's a problem, but still made me pay to have it replaced. But vw has not informed anyone, nor will take care of the problem for anyone beyond the 36000 mile warranty. $155.60. Long-term malfunction of this valve results in non-compliance. See The dealer performed a diagnostic which located the failure at the exhaust control module. The dealer said the latter is due to the misfire and in time the misfires will ruin the catalyst. We have looked the car over, ran the a/c and blower while out of the car and checked everything we can think of with no solution. ... NEW Volkswagen Jetta TDI 2005 - 2006 EGR Valve OE PIERBURG 03G131502B NEW. This hesitation happens several times per week. They confirmed code, and said not covered under any warranty. OEM VW parts come from VW and are clearly marked with the VW logo and part number and/or boxed in VW boxes or bags. I currently own two of the same model of engine as in this car and other car has never smelled like diesel exhaust in 30,000+ miles. The oil cooler has a large O ring that over time will start to leak. They have replaced a part at 9800 miles and now replacing it again at 19800miles. Owner then drove vehicle approximately 8 minutes and noticed smoke coming from the center console and the right front of the vehicle. Tl-the contact owns a 2009 Volkswagen Jetta. driving vehicle to work, started making noise and decided to drive to vw dealership.